Product ID:HEATING FUEL NO 1
MSDS Date:04/21/1990
FSC:9140
NIIN:00-247-4366
MSDS Number: BPMCZ

CHEVRON ENVIRONMENTAL HEALTH CENTER INC.

15299 SAN PABLO AVE.
RICHMOND, CA 94804
US

Emergency Phone: 415-233-3737 OR 800-457-2022

Info Phone: 415-233-3737 OR 800-582-3835

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

ALIPHATIC PETROLEUM SOLVENT/KEROSENE

CAS: 8008-20-6

RTECS: OA5500000

KEROSENE/KEROSENE, HYDRODESULFURIZED

CAS: 64742-81-0

DISTILLATES, HYDROSULFURIZED MIDDLE

CAS: 64742-80-9

OSHA PEL 5 MG/M3 OIL MIST

ACGIH TLV: 5 MG/M3 OIL MIST

DISTILLATES,STRAIGHT RUN MIDDLE

CAS: 64741-44-2

RTECS: LX3296000

OSHA PEL 5 MG/M3 OIL MIST

ACGIH TLV: 5 MG/M3 OIL MIST

NAPHTHALENE (SARA III)

CAS: 91-20-3

RTECS: QJ0525000

Fraction By Weight: < 3%

OSHA PEL 10 PPM/15 STEL

ACGIH TLV: 10 PPM/15 STEL; 9293

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:ORAL LD50 (RAT) IS > 5 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE-INHALED:PROLONGED EXPOSURE CAN
CAUSE CNS EFFECTS.SYMPTOMS ARE:HEADACHE,DIZZINESS,WEAKNESS,LOSS OF
APPETITE & COORDINATION.EYES:MILD IRRITATION.SKIN:MODERATE
IRRITATION,PAIN,BLISTERING.INGESTION: PRACTICALLY NON-TOXIC BUT IF
ASPIRATED INTO THE LUNGS,CAN CAUSE LUNG DAMAGE & DEATH.CHRONIC-MAY
CAUSE SKIN DISEASES.
Explanation of Carcinogenicity:THIS MATERIAL MAY POSE AN INCREASED RISK
OF SKIN CANCER FOLLOWING PROLONGED OR REPEATED SKIN CONTACT.
Effects of Overexposure:PROLONGED INHALATION OF VAPORS CAN CAUSE CNS
EFFECTS. SYMPTOMS ARE: HEADACHE, DIZZINESS, WEAKNESS, LOSS OF
APPETITE & COORDINATION. MILD EYE IRRITATION. MODERATE SKIN
IRRITATION, PAIN, BLISTERING. PRA CTICALLY NON-TOXIC IF INGESTED,
BUT IF ASPIRATED INTO THE LUNGS, CAN CAUSE LUNG DAMAGE & DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
MORE SUSCEPTIBLE TO THIS MATERIAL.

First Aid:GET MEDICAL CARE.INHALATION:REMOVE TO FRESH AIR.PROVIDE
CPR/OXYGEN IF NEEDED.EYE:FLUSH WITH WATER FOR 15 MINUTES KEEPING
EYELID OPEN.SKIN:WASH WITH SOAP & WATER.INGESTION:DO NOT INDUCE
VOMITING.ASPIRA TION HAZARD.IF SPONTANEOUS VOMITING OCCURS,KEEP
HEAD LOWER THAN HIPS TO PREVENT PULMONARY ASPIRATION.

Flash Point Method:TCC
Flash Point:100F,38C MIN
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. A FORCED STREAM OF WATER COULD SCATTER FLAMES OF FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. > 85F, > FIRE HAZARD
Unusual Fire/Explosion Hazard:CARBON MONOXIDE, CARBON DIOXIDE & WATER
VAPOR. FUMES CAN CATCH FIRE & BURN WITH EXPLOSIVE VIOLENCE.
INVISIBLE VAPOR CAN BE SET ON FIRE BY PILOT LIGHTS ETC...

Spill Release Procedures:REMOVE SOURCE OF HEAT,SPARKS,FLAME,FRICTION &
ELECTRICITY,INCLUDING INTERNAL COMBUSTION ENGINE.USE
EXPLOSION-PROOF EQUIPMENT TO CLEAN UP.DIKE SPILL.PREVENT LIQUID
FROM ENTERING SEWERS,WATERWAYS/LOW AR EAS.SOAK UP WITH
SAWDUST,SAND,OIL DRY.SHOVEL/SWEEP

Handling and Storage Precautions:STORAGE-STORE IN COOL,WELL-VENTILATED
AREA IN CLOSED CONTAINER AWAY FROM HEAT,IGNITION SOURCES &
OXIDIZERS.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING. EMPTY CONTAINER STILL CONTAINS HAZARDOUS
OR EXPLOSIVE VAPOR OR LIQUID. DO NOT WELD, HEAT, OR DRILL
CONTAINER. TOXIC FUMES MAY ACCUMULATE AND CAUSE DEATH.

Respiratory Protection:IF MISTS OR VAPORS PRESENT, A NIOSH-APPROVED
ORGANIC VAPOR CARTRIDGE RESPIRATOR SHOULD BE WORN. USE
SELF-CONTAINED SUPPLIED-AIR RESPIRATOR FOR EMERGENCIES.
Ventilation:GENERAL DILUTION OR MECHANICAL VENTILATION/EXPLOSION-PROOF
LOCAL EXHAUST TO KEEP VAPOR BELOW RECOMMENDED EXPOSURE LIMITS
Protective Gloves:NEOPRENE, NITRILE, OR POLYVINYL ALCOHOL
Eye Protection:USE CHEMICAL SAFETY GOGGLES & FACESHIELD
Other Protective Equipment:EYE WASH STATION.BARRIER CREAMS SPECIFIC FOR
PETROLEUM-BASED MATERIALS MAY BE USED WHEN GLOVES ARE IMPRACTICAL.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health

HCC:F4
Boiling Pt:B.P. Text:400F,204C
Spec Gravity:0.85
Viscosity:1.9 CST @ 40C
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW LIQUID

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS CHLORATES, NITRATES, PEROXIDES, ETC.
Stability Condition to Avoid:HIGH HEAT, SPARKS, OPEN FLAMES AND OTHER
SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR.
TREATMENT, STORAGE, TRANSPORTATION AND DISPOSAL MUST BE IN
ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL LAWS AND
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.